Back to all

Exhaust Service at Tuffy Tire & Auto Service Center Lewis Center in Lewis Center

July 4, 2022



Whenever they hear the term "exhaust service," most Lewis Center residents think about exhaust pipes and mufflers. Well, actually, exhaust service at Tuffy Tire & Auto Service Center Lewis Center is a lot more comprehensive these days. For example, catalytic converters were mandated in 1976 and on-board emission control computers in 1990. Governmental emissions requirements have forced manufacturers to come up with much more sophisticated ways to comply with environmental regulations.

Exhaust service has really become exhaust and emissions service. High-tech computer controlled emissions devices are now a big part of exhaust service. Because it is so sophisticated, your recommends you have your emission system checked out by a qualified Lewis Center exhaust technician regularly to make sure everything is working right - usually every 6 months or 10,000 miles/16,000 kilometers.

If your Check Engine light comes on, especially if it's flashing, get your car looked at right away. Technicians at Tuffy Tire & Auto Service Center Lewis Center in Lewis Center handle emission problems everyday. You might have exhaust or emissions trouble if your car is difficult to start, runs rough, is noisy or smoking. Call Tuffy Tire & Auto Service Center Lewis Center at 740-549-3332 to schedule an appointment if you experience these problems.


Let's review the exhaust system. We will start from the top with the exhaust manifold. That is the part that attaches to the engine and collects the exhaust from the cylinders and directs it into the exhaust pipe. Exhaust gaskets help seal the connection with the manifold and various other joints along the way. If the manifold is cracked or loose or a gasket is leaking, gases could escape into the passenger compartment where you ride. Carbon monoxide can be deadly, so it is important that your exhaust system doesn't leak. The exhaust pipes connect the various components. They can rust or be damaged by a rock, so they need to be inspected periodically.

Next is the catalytic converter. This part looks like a muffler. It changes chemicals that are dangerous to your health and our Lewis Center environment into harmless carbon dioxide and water. It doesn't require any maintenance itself. But eventually they wear out. Lewis Center drivers find this out when their car fails an emissions inspection.

Now the muffler. Its main job is to quiet engine noises. Mufflers work by either absorbing or baffling sound. And you can actually customize your car's sound with different mufflers - anything from whisper quiet to bad-boy rumbley. Rusted or road-damaged mufflers can leak and need to be replaced right away. Talk to your friendly and knowledgeable service advisor at Tuffy Tire & Auto Service Center Lewis Center .

The exhaust system is attached to the vehicle by a series of hangers and clamps. These fasteners hold the system in place. When hangers come loose or break, hot exhaust components can touch and melt wires, hoses and lines.

Finally, we end at the tailpipe. This is the final outlet for the exhaust. These can be plain-Jane or pretty flashy. Also, the oxygen sensors monitor the oxygen content of the exhaust so the engine control computer can adjust the fuel-to-air mix to keep the car running right.

Exhaust and emissions service at Tuffy Tire & Auto Service Center Lewis Center in Lewis Center covers plain old pipes and high-tech computers. It impacts everything from life-and-death safety due to exhaust leaks to fine-tuning the sound of your ride.

Tuffy Tire & Auto Service Center Lewis Center
210 Hornbeam Lane
Lewis Center, Ohio 43035
740-549-3332
http://www.tuffylewiscenter.com

More articles from Tuffy Lewis Center

A Not-So-Straight Story (Vehicle Pulls to One Side)

March 24, 2024

A vehicle should travel straight down a straight road with the steering wheel centered. But time and travel can take their toll and soon you may find your vehicle pulling to the left or right. Those are not good signs and should be taken care of fairly quickly. One thing that you should note is... More

Such a Little Part (Climate Control Resistor)

March 17, 2024

You expect your heater/air conditioner to work like it should. You have a control for temperature and one for fan speed. You even have a control for what vents the air comes out of. Don't be surprised one day if your blower fan develops a mind of its own and starts going crazy. Most of the ti... More

Things Aren't Always What They Seem

March 10, 2024

If you drive, you know at some point, something's going to go wrong with your vehicle. And sometimes, it's pretty easy to figure out what's wrong, like a flat tire. But sometimes your vehicle's symptoms can be really puzzling. One driver in Ohio was heading to work on a hot July day and noticed... More